Product ID:4010 ALL PURPOSE EPOXY
MSDS Date:09/01/1992
FSC:8010
NIIN:00N073467
MSDS Number: CCNRR

MARTIN-SENOUR CO

101 PROSPECT AVE NW
CLEVELAND, OH 44115
US

Emergency Phone: 216-566-2917

Info Phone: 216-566-2902

Cage: MART2

SHERWIN-WILLIAMS CO THE

CLEVELAND, OH 44115-1042 US

Telephone: 800-251-2486/216-566-2242

Cage: 54636

BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (EPOXY POLYMER)

CAS: 25068-38-6

RTECS: SL6475000

Fraction By Weight: 30%

OSHA PEL N/K

ACGIH TLV: N/K

CATALYST

Fraction By Weight: 30%

OSHA PEL N/K

ACGIH TLV: N/K

TALC (POWDER), CONTAINING NO ASBESTOS FIBERS; (TALC)

CAS: 14807-96-6

RTECS: WW2710000

Fraction By Weight: 20%

OSHA PEL 20 MPPCF

ACGIH TLV: 2 MG/M3 RDUST

1); (CALCIUM CARBONATE)

CAS: 471-34-1

RTECS: FF9335000

Fraction By Weight: 20%

OSHA PEL 10 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EXPOSURE MAY BE BY INHALATION AND/OR
SKIN OR EYE CONTACT, DEPENDING ON CONDITIONS OF USE. TO MINIMIZE
EXPOSURE, FOLLOW RECOMMENDATION FOR PROPER USE, VENTILATION AND
PERSONAL PROTECTIVE EQUIPMENT. ACU TE:IRRITATION OF EYES, SKIN AND
RESPIRATORY SYSTEM. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:OVEREXPOSURE MAY RESULT IN
UNCONSCIOUSNESS AND POSSIBLY DEATH. HEADACHE, DIZZINESS, NAUSEA AND
LOSS OF COORDINATION ARE INDICATIONS OF EXCESSIVE EXPOSURE TO
VAPS/SPRAY MISTS. REDNESS & ITCHIN G OR BURNING SENSATION MAY
INDICATE EYEOR EXCESSIVE SKIN EXPOSURE.
Medical Cond Aggravated by Exposure:MAY CAUSE ALLERGIC SKIN REACTION IN
SUSCEPTIBLE PERSONS.

First Aid:INHAL:REMOVE FROM EXPOSURE. RESTORE BREATHING. KEEP WARM &
QUIET. SKIN:WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. REMOVE
CONTAMINATED CLOTHING & LAUNDER BEFORE RE-USE. EYES:FLUSH W/LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGEST:SEEK MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:>199F,>93C
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT .

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. VENTILATE &
REMOVE W/INERT ABSORBENT.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DOL STORAGE CATEGORY - 3B. KEEP
CONTAINER CLOSED WHEN NOT IN USE. TRANSFER ONLY TO APPROVED
CONTAINERS W/COMPLETE & APPROPRIATE LABELING.
Other Precautions:DO NOT TAKE INTERNALLY. KEEP OUT OF THE REACH OF
CHILDREN. USE ONLY W/ADEQUATE VENTILATION. AVOID BREATHING VAPOR &
SPRAY MIST. AVOID CONTACT W/SKIN & EYES.

Respiratory Protection:IF PERSONAL EXPOSURE CANNOT BE CONTROLLED BELOW
APPLICABLE LIMITS BY VENTILATION, WEAR A PROPERLY FITTED NIOSH
APPROVED ORGANIC VAPOR/PARTICULATE RESPIRATOR FOR PROTECTION
AGAINST MATERIALS IN INGREDI ENTS SECTION.
Ventilation:LOCAL EXHAUST PREFERABLE. GENERAL EXHAUST ACCEPTABLE IF
EXPOSURE TO INGREDIENTS IS MAINTAINED BELOW APPLICABLE (SUPDAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . USE OF BARRIER CREAM ON EXPOSED SKIN IS REC.
Work Hygienic Practices:WASH HANDS AFTER USING.
Supplemental Safety and Health
VENT:EXPOSURE LIMITS. REFER TO OSHA STANDARDS 1910.94, 1910.107,
1910.108.

Vapor Density:HVR/AIR
Spec Gravity:1.25
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
NONE KNOWN.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:BY FIRE: CARBON DIOXIDE, CARBON
MONOXIDE.

Waste Disposal Methods:WASTE FROM THIS PRODUCT IS NOT HAZARDOUS AS
DEFINED UNDER RCRA (40 CFR 261). DISPOSE OF I/A/W FEDERAL, STATE &
LOCAL REGULATIONS REGARDING POLLUTION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.